Misplaced Pages

#963036

38-541: The Volkswagen LT is the largest light commercial panel van produced by Volkswagen (and subsequently Volkswagen Commercial Vehicles as of 1996) from 1975 to 2006, before being replaced by the Crafter . Two generations were produced. Volkswagen introduced the Volkswagen Type 2 in 1950 and developed light commercial vehicle versions for German and European markets. The name "Kombi" (the name under which

76-964: A 49% stake in Westfalia-Werke's van conversion division, and in 2001 absorbed the remaining 51%. Of course, since DaimlerChrysler is a Volkswagen competitor, this spelled the end of the Volkswagen-Westfalia partnership. Volkswagen still offers pop-top camper conversions in Europe, which are made in-house since 2005. Vans leave the Transporter/Multivan assembly line and are moved to a dedicated facility to be converted into Californias , in Ocean, Coast, or Beach versions. Meanwhile, Westfalia now makes Mercedes Marco Polo pop-top vans, as well as larger Sprinter high-roof — factory camper conversions for Mercedes vans, distributed in

114-455: A carburetor and a vastly uprated Porsche designed cylinder head. It was rated at 55 kilowatts (75 PS; 74 bhp) and achieved higher torque at lower engine RPMs. An inline four-cylinder diesel engine by Perkins was available. The 48 kilowatts (65 PS; 64 bhp) 2.7 L diesel was included in the LT range from 1976 onwards. The Perkins engine was replaced in 1978 with a six-cylinder variant of

152-424: A high ratio of utility space to footprint due to its forward control design and overall width of 2.085 metres (6 ft 10.1 in). The compact LT panel van (with a little over four and a half metres in length) offered an interior load length of over three metres and a load area of around 5.5 square metres. The LT was equipped with a front axle with independent front wheel suspension . Later options, such as

190-453: A larger transporter as an additional series ranged from 2.8  tons gross vehicle weight to 3.5 tons. The layout was a conventional rear drive with the engine located above the front axle , in a forward control or ' cab over ' design. The new Volkswagen van was launched in 1975 in Berlin . The name given to Volkswagen's large transporter was as functional as the entire vehicle: it

228-420: Is also up to 3.5 tonnes. Usually light haulage excludes a distribution center as the majority of deliveries are direct. A delivery may consist of a single, multiple or priority urgent load and can be either same day or next day delivery. The vehicle (as long as it doesn't exceed the 3.5 T gross vehicle weight) does not require a tachograph and can also be driven by people with a regular car license without

266-496: Is named after the company, Westfalia-Werke , the contractor that built the vans, headquartered in the town of Rheda-Wiedenbrück , located in the Westphalia region of Germany . Westfalia-Werke also converted non-Volkswagen vans and produced camping trailers and other products, but they were best known for their Volkswagen camper conversions . Westfalia began converting Volkswagen buses in 1951. Their famous "pop-top" package

304-602: The Noriker using VW LT underpinnings in competition with the Sülzer and VW LT 4x4s, but they only were produced in limited numbers. De Vries also built three VW LT 4x4s on the same principle as Sülzer/VW, one of which was used in the Dakar Rally in 1983. Out of 5 million Mk1 VW LTs built, only 1,250 featured four-wheel drive. The Volkswagen " Typ codes" for the first generation LT were: The last first-generation LT

342-659: The Volkswagen Golf diesel. The original 1.6 L four-cylinder engine became the D24 2.4 L six-cylinder , delivering 55 kW (75 PS; 74 bhp). This engine was also used in a number of Volvo passenger cars. In December 1982, an upgrade to the LT was introduced. The six-cylinder diesel was available as a turbodiesel , the Volkswagen D24T engine , producing 75 kW (102 PS; 101 bhp) and 195 N⋅m (144 lbf⋅ft) of torque. In addition,

380-631: The Ford-based Big Nugget, Volkswagen Crafter-based Sven Hedin, and the Michelangelo. The Michelangelo vehicle uses a Fiat Scudo chassis and is designed to be a major competitor to the Volkswagen California. Westfalia has recently returned to making their own conversions of Volkswagen Transporter vans, in direct competition with the Volkswagen California. On 28 January 2010, Westfalia-Werke filed for bankruptcy, citing

418-533: The LT initially went from 61 to 96 kW (83 to 131 PS; 82 to 129 bhp). In January 2002, an inline-four-cylinder 2.8 L engine made by MWM International Motores increased power output to 116 kilowatts (158 PS; 156 bhp), and the maximum torque to 331 N⋅m (244 lbf⋅ft). The 2.8 L engine specifications: The 2.5 L: Production ended in September 2006, with about 350,000 LT models produced over nine years. Plans for

SECTION 10

#1732783843964

456-560: The Type 2 was sold in Brazil) established itself as a concept term to describe an entire light commercial vehicle segment. The automaker introduced the revised Volkswagen Type 2 (T2) in 1967. Commercial customers were shipping heavier and larger-volume freight . The Volkswagen Type 2 platform was also limited by its rear-mounted engine design. A total of 471,221 series 1 LTs were produced between 1975 and 1996. The new design specifications for

494-595: The United States by Airstream and badged as Dodge Sprinters . They also provide automotive accessories to BMW, including trailer hitches. In 2008, a management buyout occurred and Westfalia Van Conversion is now an independent entity. It still converts some vehicles for major car manufacturers to sell through their own networks, such as the Ford Nugget , but also markets conversions through its own network of recreational vehicle dealers. These models include

532-517: The United States, the Westfalia conversion was by far the most common. Conversely, not all Volkswagen Westfalia conversions had pop-tops or cooking facilities. Volkswagen offered a "Weekender" package in the 1970s with a Westfalia interior, but no pop-top. Later, some Vanagon conversions were offered with a pop-top and interior table, but lacked cooking facilities and instead included a luggable 12-volt refrigerator. In 1999, DaimlerChrysler purchased

570-670: The above light commercial vehicles are sold through dealer networks. Usually, a car dealer will have a franchise for the sale of a manufacturer's cars and the LCVs will be sold as an addition. The exceptions to these are Mercedes-Benz, which has a dedicated commercial vehicle network for heavy and light commercial vehicles, Volkswagen, whose franchised dealers usually have standalone van centres, Iveco, and Isuzu Truck. Isuzu Truck market commercial vehicles up to 18 tonnes GVW and Iveco market their heavy truck range with their Daily van to complement this. Many franchised dealers also retail used LCVs, with

608-587: The change of axles, the 4x4 LTs came with different wheels to the standard LTs. All 4x4 LTs have 6 stud tube type split-rims in 6.5J width. The standard tyre fitment on these wheels is 7.00x16 or 7.50x16. In 1985 VW took over the production of the 4x4 LT and introduced the DW (2.4 inline-6 N/A diesel) and DV (2.4 inline-6 turbo-diesel) engines to the portfolio. They made another 1250 or so 4x4 LTs. The model portfolio covered only long-wheelbase vehicles. Tintop and hightop as LT40, pickup and double-cab as LT40 or LT45. In 1991

646-526: The design as the rest of the range was switching to front-wheel drive i.e. Golf/Polo/Jetta so VW came up with another design (the Scirocco). Porsche then decided to build it anyway in a collaboration with VW culminating in the Porsche 924 running with an VW EA831 Audi 2 L engine with Bosch K- Jetronic injection which is the same basic engine that was in the 2 L petrol LT at the time albeit with

684-574: The first generation of the LT, such as the Worker and Delivery trucks. In the late eighties, German-built Volkswagen LT and MAN-VW G were sold in Spain as Pegaso Ekus , while Brazilian-built units were marketed in the US as Peterbilt Midranger s. A 4X4 version of the LT was also produced. Volkswagen had already prepared for this in 1983 with the cab facelift, which incorporated instrumentation lights for

722-578: The front allowing to check the coolant without having to open the entire engine cover. A touring camper in its various bodywork and fitting options was also produced. The vehicle's width allowed the possibility of beds arranged crosswise. Various Volkswagen -endorsed Westfalia campervan models were available for the LT, including the Sven Hedin , and a later model, Florida . The LT was also used by Karmann who produced over 3,000 Karmann LT Distance Wide coachbuilt motorhomes. The "G Series" light truck

760-474: The front, centre, and rear differential locks. Sülzer developed a 6-cylinder, primarily diesel-powered, 4x4 version of the long-wheelbase VW LT, of which 156 were built. These were either LT40 or LT45 (rated 4 or 4.5 tonne). Opposed to the normal LT40 & LT45, the 4x4s only had single wheels on the rear axle. The chassis is lifted, 26mm anti-roll bars are added to cope with body-roll and the axles are replaced. A propshaft driven, rod/shaft controlled transfer box

798-423: The gross vehicle weight, with the 5.6 ton LT 55 . It was available with a single-tyre rear axle, allowing for more space between rear wheel wells inside the cargo floor. An LT with four-wheel drive that could be enabled from within the cab was also available. The next facelift in 1986 changed the round headlights to rectangular units, as well as other minor cosmetic retouches. In Spring 1993, there

SECTION 20

#1732783843964

836-569: The heavy LT 40 to LT 55 , had a solid front axle to achieve increased load-carrying capacity as is common for light trucks. The first facelift in 1983 changed mostly the interior, at the same time as the engine cover was changed and the turbo-diesel and inline-6 petrol engines were introduced. A redesigned dashboard was added and various other small things were changed. The undercarriage had an additional third wheelbase as an option for platform-type vehicles, at up to 4.6 metres in length. Two years later, Volkswagen again increased

874-571: The naturally aspirated diesel engine was dropped from the 4x4 program as it did not have enough power for the 4x4 drivetrain, with most 4x4 LTs being either the 90 bhp 6-cyl petrol or the 102 bhp 6-cyl D24T. From 1993 on, VW introduced the D24TIC with 95 bhp, but more torque, for the LT (and LT 4x4). At the same time the transfer box was upgraded to the New Process 241. Steyr-Puch in Austria built

912-532: The need for an Operator's License . The speed restriction is higher than heavy goods vehicles: 60 MPH on dual carriageways and up to 70 MPH on motorways. Qualifying light commercial vehicles include pickup trucks , vans and three-wheelers – all commercially based goods or passenger carrier vehicles. The LCV concept was created as a compact truck and is usually optimised to be tough-built, have low operating costs and powerful yet fuel efficient engines, and to be used in intra-city operations. All of

950-499: The poorer quality examples sent to specialist auctions for sale. There is a large network of independent used commercial vehicle retailers who retail thousands of used commercial vehicles every month. LCV dealers are increasingly using the Internet to help sell their vehicles in addition to the traditional print media. Westfalia Westfalia is the designation of various specially converted Volkswagen camper vans . Westfalia

988-533: The range. A special articulated version of the second generation LT, the XLT was available through special order. The Volkswagen " Typ codes" for the second generation LT are: Engines included a naturally aspirated engine, as well as three Turbocharged Direct Injection (TDI) diesel engines. These were the inline-five-cylinder TDI used in the Volkswagen Eurovan (Type 2 T4). The performance range for

1026-470: The second generation LT. The Volkswagen version shared the body shell with the new Mercedes-Benz Sprinter . However, the engine and transmission were Volkswagen Group sourced. This deal would continue in the Volkswagen Crafter , a successor to the LT. The new design incorporated an engine mounted longitudinally beneath a short hood and with rear-wheel drive . The LT adopted what had become

1064-404: The six-cylinder engine was now also available as a 66 kW (90 PS; 89 bhp) petrol engine. All engines were now mounted with a clear offset alignment that allowed for a flatter engine compartment, which was shifted further to the rear for more space for a third seat in the cab . In 1992, an overhauled turbo-diesel engine with charge air cooler and 70 kW (95 PS; 94 bhp)

1102-484: The standard style of construction for bigger transporters. It also included economical direct-injection diesel engines , easy access to the driver cab behind the front axle , and a wide space between the driver and passenger seat. The range now went from 2.6 to 4.6  tons gross vehicle weight , and the enclosed options of the panel van and compact were available in three wheelbase options. Platform vehicles, crew cabs, and numerous undercarriage options completed

1140-458: The third generation of the 'large transporter' from Volkswagen Commercial Vehicles were canceled and later that year, the Volkswagen Crafter was launched. Concepts and future models: Microbus Concept Light commercial vehicle In the UK, light haulage is a restricted-weight delivery service where the maximum permitted gross vehicle weight rating without the need of an operator's license

1178-479: The transition to the cardan shaft further ahead, or a shorter shaft. Axles for single tires cannot be installed in vehicles with twin tires and vice versa. LT 1 4x4 axles are completely different and cannot be replaced by other LT axles. A full list of code letter explanations is available on the German VW LT wiki. In 1996, the joint venture of Volkswagen and Daimler 's Mercedes-Benz Commercial introduced

Volkswagen LT - Misplaced Pages Continue

1216-430: Was a joint venture between Volkswagen and MAN AG , with gross vehicle weights of between six and ten tons. It was built from 1979 until 1993. Volkswagen's Brazilian plant at Resende has been constructing trucks with weights of between 7 and 35 tons. Even after the launch of the new Volkswagen Constellation in 2006, Volkswagen Commercial Vehicles has continued to manufacture vehicles incorporating cabs based on

1254-714: Was added later and became very popular on the second-generation VW Bus from 1968 to 1979, and its successor the Vanagon (also calle Westy and Campmobile ), the Sven Hedin and Florida conversions on the Volkswagen LT , and then the T4 EuroVan , which was discontinued in 2003. This design also inspired many imitators, with dozens of other companies worldwide offering pop-top van conversions. Therefore, not all pop-top Volkswagens are Westfalia conversions, although in

1292-532: Was again a modest change in the look, with new grey-plastic elements introduced to the radiator grille and in the rear lighting section. The diesel engines were replaced with a more modern version of the same block. The DW (N/A diesel) was replaced by the ACT engine and the DV (turbo-diesel) engines were replaced by the intercooled ACL engine. Additionally, the engine cover was replaced with a new version, that had an opening in

1330-703: Was installed under the vehicle. The transfer box was a New Process 208, which is propshaft-driven and cable-operated. The same transfer box can also be found in Chevrolet Blazers and Jeep Cherokees of around the same time. The first six of the Sülzer vehicles are supposed to have had Dana 70 axles. After that production was changed to use the Italian-built Clark-Hurth axles. All 4x4 LTs came as standard with rear and centre locking differentials, with optional front diff-lock also available (until it became standard fitment in 1991). Due to

1368-515: Was introduced – the Volkswagen D24TIC engine . Early DV/ACL engine valves are mechanically shimmed; later versions were hydraulically auto-adjusted. The ACL had bigger injectors and the addition of the intercooler. The main block and bottom end remained identical. The head/valve adjusters/injectors/intake manifold and the turbo had variants plus a different sump for the oil to be pumped to the turbo. Turbodiesel axles are reinforced, have

1406-439: Was just called LT , which is simply the abbreviation of Lasten-Transporter (that basically means heavy load transporter or cargo transporter ). The LT came in three gross vehicle weights, from 2.8 to 3.5  tons ( LT 28 , LT 31 , LT 35 ), with two wheelbases , two roof options, and with bodywork options as a panel van , a compact, a platform vehicle, and a chassis cab combination. The design featured

1444-462: Was produced in 1996, which corresponds to a British 'P' registration plate. In 21 years, just under 500,000 vehicles were assembled. The petrol engine was a modified Audi 100 VW EA831 2.0 L inline four-cylinder. In 1976 Volkswagen wanted to make a sports coupe and had Porsche design one for them using parts from the VW/Audi group bin with front engine and rear-wheel drive. They did not go with

#963036