61-493: The Rolls-Royce RB.53 Dart is a turboprop engine designed and manufactured by Rolls-Royce Limited . First run in 1946, it powered the Vickers Viscount on its maiden flight in 1948. A flight on July 29 of that year, which carried 14 paying passengers between Northolt and Paris–Le Bourget Airport in a Dart-powered Viscount, was the first regularly scheduled airline flight by a turbine-powered aircraft. The Viscount
122-577: A gas mask . Diesel exhaust is the exhaust gas produced by a diesel engine , plus any contained particulates . Its composition may vary with the fuel type, rate of consumption or speed of engine operation (e.g., idling or at speed or under load), and whether the engine is in an on-road vehicle, farm vehicle, locomotive, marine vessel, or stationary generator or other application. Diesel exhaust causes lung cancer and other diseases such as asthma , and many premature deaths. Methods exist to reduce nitrogen oxides (NO x ) and particulate matter (PM) in
183-520: A tailpipe filter installed, while the United States has mandated it for diesel only. In 2022, British testing specialist Emissions Analytics estimated that the 300 million or so gasoline vehicles in the US over the subsequent decade would emit around 1.6 septillion harmful particles. Carbon dioxide is a greenhouse gas . Motor vehicle CO 2 emissions are part of the anthropogenic contribution to
244-420: A catalytic converter up to 100,000 ppm (10%) for a richly tuned carburetor engine, such as typically found on small generators and garden equipment. Exhaust gas from an internal combustion engine whose fuel includes nitromethane will contain nitric acid vapour, which is corrosive, and when inhaled causes a muscular reaction making it impossible to breathe. People who are likely to be exposed to it should wear
305-406: A constant-speed propeller increase their pitch as aircraft speed increases. Another benefit of this type of propeller is that it can also be used to generate reverse thrust to reduce stopping distance on the runway. Additionally, in the event of an engine failure, the propeller can be feathered , thus minimizing the drag of the non-functioning propeller. While the power turbine may be integral with
366-416: A large amount of air by a small degree than a small amount of air by a large degree, a low disc loading (thrust per unit disc area) increases the aircraft's energy efficiency , and this reduces the fuel use. Propellers work well until the flight speed of the aircraft is high enough that the airflow past the blade tips reaches the speed of sound. Beyond that speed, the proportion of the power that drives
427-414: A pattern called an exhaust plume . It is a major component of motor vehicle emissions (and from stationary internal combustion engines ), which can also include crankcase blow-by and evaporation of unused gasoline. Air pollution from burning fossil fuels is estimated to kill over 5 million people each year. Motor vehicle emissions are a common source of air pollution and are a major ingredient in
488-471: A team led by Lionel Haworth, the Dart engine was derived using experience gained from the earlier more powerful Rolls-Royce Clyde turboprop. A two-stage centrifugal compressor was specified to achieve the desired overall pressure ratio. A 3 stage, shared load, axial turbine was used to drive both the load (via a reduction gearbox) and the compression system. A photo showing a cutaway section of typical Dart engine
549-591: A test-bed not intended for production. It first flew on 20 September 1945. From their experience with the Trent, Rolls-Royce developed the Rolls-Royce Clyde , the first turboprop engine to receive a type certificate for military and civil use, and the Dart , which became one of the most reliable turboprop engines ever built. Dart production continued for more than fifty years. The Dart-powered Vickers Viscount
610-429: Is a turbine engine that drives an aircraft propeller . A turboprop consists of an intake , reduction gearbox , compressor , combustor , turbine , and a propelling nozzle . Air enters the intake and is compressed by the compressor. Fuel is then added to the compressed air in the combustor, where the fuel-air mixture then combusts . The hot combustion gases expand through the turbine stages, generating power at
671-539: Is colorless, odorless and tasteless, but highly toxic. It combines with hemoglobin to produce carboxyhemoglobin , which blocks the transport of oxygen. At concentrations above 1000ppm it is considered immediately dangerous and is the most immediate health hazard from running engines in a poorly ventilated space. In 2011, 52% of carbon monoxide emissions were created by mobile vehicles in the U.S. Chronic (long-term) exposure to benzene ( C 6 H 6 ) damages bone marrow . It can also cause excessive bleeding and depress
SECTION 10
#1732772291341732-730: Is estimated to kill over 5 million people each year. A 2013 study by the Massachusetts Institute of Technology (MIT) indicates that 53,000 early deaths occur per year in the United States alone because of vehicle emissions. According to another study from the same university, traffic fumes alone cause the death of 5,000 people every year just in the United Kingdom. Researchers from the University of California, Los Angeles School of Public Health say preliminary results of their statistical study of children listed in
793-508: Is given below. Unlike the Clyde, the engine lacked a free power turbine. Consequently, under normal operating conditions, the power delivered to the propeller could not be modulated at a fixed prop speed. The Dart was initially rated at 890 shp and first flew in October 1947 mounted to the nose of a converted Avro Lancaster . Improvements in the design boosted power output to 1,400 shp in
854-435: Is important to the functioning of the catalytic converter of an internal combustion engine . It may be measured by an exhaust gas temperature gauge . EGT is also a measure of engine health in gas-turbine engines (see below). During the first two minutes after starting the engine of a car that has not been operated for several hours, the amount of emissions can be very high. This occurs for two main reasons: Comparable with
915-482: Is normally a constant-speed (variable pitch) propeller type similar to that used with larger aircraft reciprocating engines , except that the propeller-control requirements are very different. Due to the turbine engine's slow response to power inputs, particularly at low speeds, the propeller has a greater range of selected travel in order to make rapid thrust changes, notably for taxi, reverse, and other ground operations. The propeller has 2 modes, Alpha and Beta. Alpha
976-494: Is sacrificed in favor of shaft power, which is obtained by extracting additional power (beyond that necessary to drive the compressor) from turbine expansion. Owing to the additional expansion in the turbine system, the residual energy in the exhaust jet is low. Consequently, the exhaust jet produces about 10% of the total thrust. A higher proportion of the thrust comes from the propeller at low speeds and less at higher speeds. Turboprops have bypass ratios of 50–100, although
1037-534: Is that emitted from ovens, furnaces and boilers. In steam engine terminology the exhaust is steam that is now so low in pressure that it can no longer do useful work. Mono- nitrogen oxides NO and NO 2 ( NOx ) (whether produced this way or naturally by lightning ) react with ammonia , moisture, and other compounds to form nitric acid vapor and related particles. Small particles can penetrate deeply into sensitive lung tissue and damage it, causing premature death in extreme cases. Inhalation of NO species increases
1098-404: Is the mode for all flight operations including takeoff. Beta, a mode typically consisting of zero to negative thrust, is used for all ground operations aside from takeoff. The Beta mode is further broken down into 2 additional modes, Beta for taxi and Beta plus power. Beta for taxi as the name implies is used for taxi operations and consists of all pitch ranges from the lowest alpha range pitch, all
1159-404: Is undesirable, noxious, or toxic substances, such as carbon monoxide (CO) from incomplete combustion, hydrocarbons (properly indicated as C x H y , but typically shown simply as "HC" on emissions-test slips) from unburnt fuel, nitrogen oxides (NO x ) from excessive combustion temperatures, and particulate matter (mostly soot ) from incomplete combustion. Exhaust gas temperature (EGT)
1220-440: Is useful to growing plants. When oxides of nitrogen (NOx) and volatile organic compounds (VOCs) react in the presence of sunlight, ground level ozone is formed, a primary ingredient in smog . A 2005 U.S. EPA report gives road vehicles as the second largest source of VOCs in the U.S. at 26% and 19% are from non road equipment which is mostly gasoline and diesel stations. 27% of VOC emissions are from solvents which are used in
1281-568: The European emission standards EURO III as it was applied in October 2000 In 2000, the United States Environmental Protection Agency began to implement more stringent emissions standards for light duty vehicles. The requirements were phased in beginning with 2004 vehicles and all new cars and light trucks were required to meet the updated standards by the end of 2007. In spark-ignition engines
SECTION 20
#17327722913411342-634: The P-3 Orion , and the C-130 Hercules military transport aircraft. The first turbine-powered, shaft-driven helicopter was the Kaman K-225 , a development of Charles Kaman 's K-125 synchropter , which used a Boeing T50 turboshaft engine to power it on 11 December 1951. December 1963 saw the first delivery of Pratt & Whitney Canada's PT6 turboprop engine for the then Beechcraft 87, soon to become Beechcraft King Air . 1964 saw
1403-841: The Piper Meridian , Socata TBM , Pilatus PC-12 , Piaggio P.180 Avanti , Beechcraft King Air and Super King Air . In April 2017, there were 14,311 business turboprops in the worldwide fleet. Between 2012 and 2016, the ATSB observed 417 events with turboprop aircraft, 83 per year, over 1.4 million flight hours: 2.2 per 10,000 hours. Three were "high risk" involving engine malfunction and unplanned landing in single‑engine Cessna 208 Caravans , four "medium risk" and 96% "low risk". Two occurrences resulted in minor injuries due to engine malfunction and terrain collision in agricultural aircraft and five accidents involved aerial work: four in agriculture and one in an air ambulance . Jane's All
1464-614: The Tupolev Tu-114 can reach 470 kn (870 km/h; 540 mph). Large military aircraft , like the Tupolev Tu-95 , and civil aircraft , such as the Lockheed L-188 Electra , were also turboprop powered. The Airbus A400M is powered by four Europrop TP400 engines, which are the second most powerful turboprop engines ever produced, after the 11 MW (15,000 hp) Kuznetsov NK-12 . In 2017,
1525-410: The immune system , increasing the chance of infection . Benzene causes leukemia and is associated with other blood cancers and pre-cancers of the blood. The health effects of inhaling airborne particulate matter have been widely studied in humans and animals and include asthma , lung cancer , cardiovascular issues, premature death . Because of the size of the particles, they can penetrate
1586-662: The RDa.3, which went into production for the Viscount in 1952. The RDa.6 increased power to 1,600 shp and the RDa.7 to 1,800 shp by incorporating various improvements including a larger diameter second impeller. Later Darts were rated up to 3,245 shp and remained in production until 1987, with approximately 7,100 produced, flying some 170 million hours. The Dart was also produced under licence in India by Hindustan Aeronautics Limited . Haworth and his team later went on to design and develop
1647-533: The Soviet Union had the technology to create the airframe for a jet-powered strategic bomber comparable to Boeing's B-52 Stratofortress , they instead produced the Tupolev Tu-95 Bear, powered with four Kuznetsov NK-12 turboprops, mated to eight contra-rotating propellers (two per nacelle) with supersonic tip speeds to achieve maximum cruise speeds in excess of 575 mph, faster than many of
1708-461: The World's Aircraft . 2005–2006. Exhaust gas Exhaust gas or flue gas is emitted as a result of the combustion of fuels such as natural gas , gasoline (petrol) , diesel fuel , fuel oil , biodiesel blends, or coal . According to the type of engine, it is discharged into the atmosphere through an exhaust pipe , flue gas stack , or propelling nozzle . It often disperses downwind in
1769-417: The compressor intake is at the aft of the engine, and the exhaust is situated forward, reducing the distance between the turbine and the propeller. Unlike the small-diameter fans used in turbofan engines, the propeller has a large diameter that lets it accelerate a large volume of air. This permits a lower airstream velocity for a given amount of thrust. Since it is more efficient at low speeds to accelerate
1830-459: The control system. The turboprop system consists of 3 propeller governors , a governor, and overspeed governor, and a fuel-topping governor. The governor works in much the same way a reciprocating engine propeller governor works, though a turboprop governor may incorporate beta control valve or beta lift rod for beta operation and is typically located in the 12 o'clock position. There are also other governors that are included in addition depending on
1891-407: The creation of smog in some large cities. The largest part of most combustion gas is nitrogen (N 2 ), water vapor (H 2 O) (except with pure-carbon fuels), and carbon dioxide (CO 2 ) (except for fuels without carbon); these are not toxic or noxious (although water vapor and carbon dioxide are greenhouse gases that contribute to climate change ). A relatively small part of combustion gas
Rolls-Royce Dart - Misplaced Pages Continue
1952-452: The deepest part of the lungs. A 2011 UK study estimates 90 deaths per year due to passenger vehicle PM. In a 2006 publication, the U.S. Federal Highway Administration (FHWA) state that in 2002 about 1 per-cent of all PM 10 and 2 per-cent of all PM 2.5 emissions came from the exhaust of on-road motor vehicles (mostly from diesel engines ). In Chinese, European, and Indian markets, both diesel and gasoline vehicles are required to have
2013-491: The exhaust. In aircraft gas turbine engines, "exhaust gas temperature" (EGT) is a primary measure of engine health. Typically the EGT is compared with a primary engine power indication called "engine pressure ratio" (EPR). For example: at full power EPR there will be a maximum permitted EGT limit. Once an engine reaches a stage in its life where it reaches this EGT limit, the engine will require specific maintenance in order to rectify
2074-499: The first jet aircraft and comparable to jet cruising speeds for most missions. The Bear would serve as their most successful long-range combat and surveillance aircraft and symbol of Soviet power projection through to the end of the 20th century. The USA used turboprop engines with contra-rotating propellers, such as the Allison T40 , on some experimental aircraft during the 1950s. The T40-powered Convair R3Y Tradewind flying-boat
2135-564: The first deliveries of the Garrett AiResearch TPE331 , (now owned by Honeywell Aerospace ) on the Mitsubishi MU-2 , making it the fastest turboprop aircraft for that year. In contrast to turbofans , turboprops are most efficient at flight speeds below 725 km/h (450 mph; 390 knots) because the jet velocity of the propeller (and exhaust) is relatively low. Modern turboprop airliners operate at nearly
2196-570: The gas generator section, many turboprops today feature a free power turbine on a separate coaxial shaft. This enables the propeller to rotate freely, independent of compressor speed. Alan Arnold Griffith had published a paper on compressor design in 1926. Subsequent work at the Royal Aircraft Establishment investigated axial compressor-based designs that would drive a propeller. From 1929, Frank Whittle began work on centrifugal compressor-based designs that would use all
2257-460: The gas power produced by the engine for jet thrust. The world's first turboprop was designed by the Hungarian mechanical engineer György Jendrassik . Jendrassik published a turboprop idea in 1928, and on 12 March 1929 he patented his invention. In 1938, he built a small-scale (100 Hp; 74.6 kW) experimental gas turbine. The larger Jendrassik Cs-1 , with a predicted output of 1,000 bhp,
2318-480: The gases resulting from combustion of the fuel and air mix are called exhaust gases. The composition varies from petrol to diesel engines, but is around these levels: The 10% oxygen for "diesel" is likely if the engine was idling, e.g. in a test rig. It is much less if the engine is running under load, although diesel engines always operate with an excess of air over fuel. The CO content for petrol engines varies from ≈15 ppm for well tuned engine with fuel injection and
2379-590: The growth of CO 2 concentrations in the atmosphere which according to the vast majority of the scientific community is causing climate change . Motor vehicles are calculated to generate about 20% of the European Union's man-made CO 2 emissions, with passenger cars contributing about 12%. European emission standards limit the CO 2 emissions of new passenger cars and light vehicles. The European Union average new car CO 2 emissions figure dropped by 5.4% in
2440-528: The larger and more powerful Rolls-Royce Tyne . As well as the RB.53 designation each mark of Dart engine was allocated a Ministry of Supply (MoS) "RDa.n" number as well as Mk.numbers. Largely associated with the very successful Vickers Viscount medium-range airliner , it powered a number of other European and Japanese designs of the 1950s and 60s and was also used to convert American-manufactured piston aircraft to turboprop power. The list includes: Power output
2501-402: The manufacturer of paints and paint thinners and other uses. Ozone is beneficial in the upper atmosphere, but at ground level ozone irritates the respiratory system , causing coughing, choking, and reduced lung capacity. It also has many negative effects throughout the ecosystem. Carbon monoxide poisoning is the most common type of fatal air poisoning in many countries. Carbon monoxide
Rolls-Royce Dart - Misplaced Pages Continue
2562-406: The model, such as an overspeed and fuel topping governor on a Pratt & Whitney Canada PT6 , and an under-speed governor on a Honeywell TPE331 . The turboprop is also distinguished from other kinds of turbine engine in that the fuel control unit is connected to the governor to help dictate power. To make the engine more compact, reverse airflow can be used. On a reverse-flow turboprop engine,
2623-671: The most widespread turboprop airliners in service were the ATR 42 / 72 (950 aircraft), Bombardier Q400 (506), De Havilland Canada Dash 8 -100/200/300 (374), Beechcraft 1900 (328), de Havilland Canada DHC-6 Twin Otter (270), Saab 340 (225). Less widespread and older airliners include the BAe Jetstream 31 , Embraer EMB 120 Brasilia , Fairchild Swearingen Metroliner , Dornier 328 , Saab 2000 , Xian MA60 , MA600 and MA700 , Fokker 27 and 50 . Turboprop business aircraft include
2684-416: The pilot not being able to see out of the rear of the aircraft for backing and the amount of debris reverse stirs up, manufacturers will often limit the speeds beta plus power may be used and restrict its use on unimproved runways. Feathering of these propellers is performed by the propeller control lever. The constant-speed propeller is distinguished from the reciprocating engine constant-speed propeller by
2745-403: The point of exhaust. Some of the power generated by the turbine is used to drive the compressor and electric generator . The gases are then exhausted from the turbine. In contrast to a turbojet or turbofan , the engine's exhaust gases do not provide enough power to create significant thrust, since almost all of the engine's power is used to drive the propeller. Exhaust thrust in a turboprop
2806-407: The pollution of exhaust gases using a catalyst. Scrubbers in ships intend to remove the sulfur dioxide (SO 2 ) of marine exhaust gases. The regulations on marine sulfur dioxide emissions are tightening, however only a small number of special areas worldwide have been designated for low sulfur diesel fuel use only. Air pollution from fossil fuel use by industry, power generation, and transportation
2867-430: The problem. The amount the EGT is below the EGT limit is called EGT margin. The EGT margin of an engine will be greatest when the engine is new, or has been overhauled. For most airlines, this information is also monitored remotely by the airline maintenance department by means of ACARS . In jet engines and rocket engines , exhaust from propelling nozzles which in some applications shows shock diamonds . Flue gas
2928-494: The propeller that is converted to propeller thrust falls dramatically. For this reason turboprop engines are not commonly used on aircraft that fly faster than 0.6–0.7 Mach , with some exceptions such as the Tupolev Tu-95 . However, propfan engines, which are very similar to turboprop engines, can cruise at flight speeds approaching 0.75 Mach. To maintain propeller efficiency across a wide range of airspeeds, turboprops use constant-speed (variable-pitch) propellers. The blades of
2989-485: The propeller. This allows for propeller strike or similar damage to occur without damaging the gas generator and allowing for only the power section (turbine and gearbox) to be removed and replaced in such an event, and also allows for less stress on the start during engine ground starts. Whereas a fixed shaft has the gearbox and gas generator connected, such as on the Honeywell TPE331 . The propeller itself
3050-450: The propulsion airflow is less clearly defined for propellers than for fans. The propeller is coupled to the turbine through a reduction gear that converts the high RPM /low torque output to low RPM/high torque. This can be of two primary designs, free-turbine and fixed. A free-turbine turboshaft found on the Pratt & Whitney Canada PT6 , where the gas generator is not connected to
3111-481: The risk of lung cancer and colorectal cancer. and inhalation of such particles may cause or worsen respiratory diseases such as emphysema and bronchitis and heart disease. In a 2005 U.S. EPA study the largest emissions of NO x came from on road motor vehicles, with the second largest contributor being non-road equipment which is mostly gasoline and diesel stations. The resulting nitric acid may be washed into soil, where it becomes nitrate , which
SECTION 50
#17327722913413172-592: The same speed as small regional jet airliners but burn two-thirds of the fuel per passenger. Compared to piston engines, their greater power-to-weight ratio (which allows for shorter takeoffs) and reliability can offset their higher initial cost, maintenance and fuel consumption. As jet fuel can be easier to obtain than avgas in remote areas, turboprop-powered aircraft like the Cessna Caravan and Quest Kodiak are used as bush airplanes . Turboprop engines are generally used on small subsonic aircraft, but
3233-410: The way down to zero pitch, producing very little to zero-thrust and is typically accessed by moving the power lever to a beta for taxi range. Beta plus power is a reverse range and produces negative thrust, often used for landing on short runways where the aircraft would need to rapidly slow down, as well as backing operations and is accessed by moving the power lever below the beta for taxi range. Due to
3294-692: The year to the first quarter of 2010, down to 145.6 g/km . Vehicle exhaust contains much water vapour . There has been research into ways that troops in deserts can recover drinkable water from their vehicles' exhaust gases. Emission standards focus on reducing pollutants contained in the exhaust gases from vehicles as well as from industrial flue gas stacks and other air pollution exhaust sources in various large-scale industrial facilities such as petroleum refineries , natural gas processing plants, petrochemical plants and chemical production plants. However, these are often referred to as flue gases . Catalytic converters in cars intend to break down
3355-477: Was around 1,500 hp (1,120 kW) in early versions, and close to twice that in later versions, such as those that powered the NAMC YS-11 airliner. Some versions of the engine were fitted with water methanol injection, which boosted power in hot and high altitude conditions. Data from Jane's All The World's Aircraft 1965–66. Comparable engines Related lists Turboprop A turboprop
3416-514: Was destroyed in a bombing raid. In 1941, the engine was abandoned due to war, and the factory converted to conventional engine production. The first mention of turboprop engines in the general public press was in the February 1944 issue of the British aviation publication Flight , which included a detailed cutaway drawing of what a possible future turboprop engine could look like. The drawing
3477-714: Was operated by the U.S. Navy for a short time. The first American turboprop engine was the General Electric XT31 , first used in the experimental Consolidated Vultee XP-81 . The XP-81 first flew in December 1945, the first aircraft to use a combination of turboprop and turbojet power. The technology of Allison's earlier T38 design evolved into the Allison T56 , used to power the Lockheed Electra airliner, its military maritime patrol derivative
3538-647: Was produced and tested at the Ganz Works in Budapest between 1937 and 1941. It was of axial-flow design with 15 compressor and 7 turbine stages, annular combustion chamber. First run in 1940, combustion problems limited its output to 400 bhp. Two Jendrassik Cs-1s were the engines for the world's first turboprop aircraft – the Varga RMI-1 X/H . This was a Hungarian fighter-bomber of WWII which had one model completed, but before its first flight it
3599-603: Was the first turboprop aircraft of any kind to go into production and sold in large numbers. It was also the first four-engined turboprop. Its first flight was on 16 July 1948. The world's first single engined turboprop aircraft was the Armstrong Siddeley Mamba -powered Boulton Paul Balliol , which first flew on 24 March 1948. The Soviet Union built on German World War II turboprop preliminary design work by Junkers Motorenwerke, while BMW, Heinkel-Hirth and Daimler-Benz also worked on projected designs. While
3660-479: Was the first turboprop-powered aircraft to enter airline service - British European Airways (BEA) in 1953. The Dart was still in production forty years later when the last Fokker F27 Friendships and Hawker Siddeley HS 748s were produced in 1987. Following the company's convention for naming gas turbine engines after rivers, this turboprop engine design was named after the River Dart . Designed in 1946 by
3721-488: Was very close to what the future Rolls-Royce Trent would look like. The first British turboprop engine was the Rolls-Royce RB.50 Trent , a converted Derwent II fitted with reduction gear and a Rotol 7 ft 11 in (2.41 m) five-bladed propeller. Two Trents were fitted to Gloster Meteor EE227 — the sole "Trent-Meteor" — which thus became the world's first turboprop-powered aircraft to fly, albeit as
SECTION 60
#1732772291341#340659