Open-pit mining , also known as open-cast or open-cut mining and in larger contexts mega-mining , is a surface mining technique that extracts rock or minerals from the earth.
93-553: The Bingham Canyon Mine , more commonly known as Kennecott Copper Mine among locals, is an open-pit mining operation extracting a large porphyry copper deposit southwest of Salt Lake City , Utah , in the Oquirrh Mountains . The mine is the largest human-made excavation, and deepest open-pit mine in the world, which is considered to have produced more copper than any other mine in history – more than 19,000,000 short tons (17,000,000 long tons; 17,000,000 t). The mine
186-609: A National Historic Landmark District administered by the National Park Service . It was declared a National Historic Landmark in 1986. In the summer of 1900, two prospectors , "Tarantula" Jack Smith and Clarence L. Warner, a group of prospectors associated with the McClellan party, spotted "a green patch far above them in an improbable location for a grass-green meadow." The green turned out to be malachite , located with chalcocite (aka "copper glance") , and
279-573: A USGS geologist by the name of Oscar Rohn in 1899. This original copper find became the basis of the Nikolai Mine in 1900. Simultaneously, placer gold was discovered on the Dan and Young Creeks. The Bonanza ore body was discovered in Aug. 1900 by Warner and Smith. Almost simultaneously, another USGS geologist named Arthur Spencer, came across the ore when mapping the area with Frank Schrader. In 1901,
372-561: A net profit greater than $ 100 million. In 1938, Ernest Gruening proposed Kennecott be preserved as a National Park. A recommendation to President Franklin D. Roosevelt on January 18, 1940, for the establishment of the Kennecott National Monument went nowhere. However, December 2, 1980, saw the establishment of the Wrangell-St. Elias National Park and Preserve . From 1939 until the mid-1950s, Kennecott
465-469: A 25 percent financial interest in Utah Copper in 1915, which increased to 75 percent in 1923. Bingham's Canyon mine expanded rapidly, and by the 1920s, the region was a beehive of activity. Some 15,000 people of widely varying ethnicity lived in the canyon in large residential communities constructed on the steep canyon walls. The population declined rapidly as mining techniques improved, and several of
558-545: A concentric alteration pattern and mineralogic zonation around the Bingham stock . These zones include a central core containing magnetite , followed by "a molybdenite zone low in copper, a bornite - chalcopyrite -gold higher grade copper zone, a pyrite -chalcopyrite zone, a pyrite zone, and an outermost lead-zinc zone." Structurally , Late Paleozoic rocks were thrust faulted over the Precambrian craton during
651-751: A financial interest in the copper. The Alaska Syndicate traded its Wrangell Mountains Mines assets for shares in the Kennecott Copper Corporation , a "new public company" formed on April 29, 1915. A similar transaction followed with the CR&;NW railway and the Alaska Steamship Company . Birch was the managing partner for the Alaska operation. Kennecott Mines was named after the Kennicott Glacier in
744-473: A fleet of 64 large dump trucks which each carry 255 short tons (228 long tons; 231 t) of ore at a time; the trucks themselves cost about $ 3 million each. There is a five-mile (8 km) series of conveyors that take ore to the Copperton concentrator and flotation plant. The longest conveyor is 3 miles (4.8 km) long. As of 2010, Kennecott Utah Copper was the second largest copper producer in
837-463: A glacial trail from Kennecott. Ore was hoisted to Kennecott via the trams which head-ended at Bonanza and Jumbo. From Kennecott the ore was hauled mostly in 140-pound sacks on steel flat cars to Cordova , 196 rail miles away, via the Copper River and Northwestern Railway (CRNW). In 1911 the first shipment of ore by train transpired. Before completion, the steamship Chittyna carried ore to
930-483: A landslide occurred at the mine. Around 2.3–2.5 billion cubic feet (65 × 10 ^ –70 × 10 ^ m) of dirt and rock thundered down the side of the pit. It is possibly the largest historic non-volcanic landslide in North America. On the basis that the mine's steep walls made it a high risk for landslides, an interferometric radar system had been previously installed to monitor the ground's stability. As
1023-474: A million short tons (910 kt or 890 thousand long tons) of sulfuric acid, a by-product of the smelting process. Rio Tinto purchased Kennecott Utah Copper in 1989 and has invested about $ 2 billion in the modernization of KUC's operations. Bingham Canyon has proven to be one of the world's most productive mines. As of 2004, its ore yielded more than 17 million tons of copper, 715 tons of gold, 5,900 tons of silver , and 425,000 tons of molybdenum . The value of
SECTION 10
#17327729768971116-447: A mine that contribute to this load: drilling , blasting, loading, and hauling . Waste rock is hauled to a waste dump. Waste dumps can be piled at the surface of the active pit, or in previously mined pits. Leftover waste from processing the ore is called tailings , and is generally in the form of a slurry . This is pumped to a tailings dam or settling pond, where the water is reused or evaporated. Tailings dams can be toxic due to
1209-561: A mining claim in accordance with the Stock-Raising Homestead Act of 1916. In 2008, the United States Department of Interior Fish and Wildlife Service sued Kennecott after the release of hazardous substances including selenium , copper, arsenic , zinc , lead , and cadmium . A federal biologist claimed that these chemicals have caused great damage to the ecosystems and resources that support
1302-429: A number of worked-out mines. After mining ends at a location, the mine area may undergo land rehabilitation . Waste dumps are contoured to flatten them out, to further stabilize them. If the ore contains sulfides it is usually covered with a layer of clay to prevent ingress of rain and oxygen from the air, which can oxidize the sulfides to produce sulfuric acid , a phenomenon known as acid mine drainage . This
1395-477: A result of room and pillar mining . Untopping removes the overburden from above this, opens up the mine from above, and then allows the previously 'trapped' minerals to be won. Untopping was a feature of Welsh slate workings in the 1930s and 2000s, where Martyn Williams-Ellis, manager at Llechwedd found that earlier Victorian workings could be kept profitable with the newly mechanised techniques for bulk excavation to extract their pillars, and more recently across
1488-459: A result of warnings produced by this system, mining operations had been shut down the previous day in anticipation of the slide and there were no injuries. The massive slide was expected to cut production of mined copper by 100,000 tonnes (98,000 long tons; 110,000 short tons). A second slide caused an evacuation of 100 workers on September 11, 2013. Another, less severe slide occurred on May 31, 2021. Similar to other industrial age mining operations,
1581-674: A somewhat terrifying scramble along cliffs overlooking the Stairway Icefall. Local guide services offer all of these hikes if one would like some route-finding assistance. Kennecott is now accessible by air (McCarthy has a 3,500 foot (1,100 m) meter gravel runway) or by driving on the Edgerton Highway to the McCarthy Road , an unimproved gravel road. The McCarthy Road ends at the Kennicott River and
1674-438: A very high boiling point of 4,644 °F (2,562 °C) and also requires use of other chemicals to separate it from other metals and impurities present in the ore. Asbestos has microscopic particles that dispersed into the atmosphere and contributed to illnesses among workers and individuals living near the mines. Asbestos is responsible for illnesses such as pleural fibrosis, skin warts and lung cancer . Kennecott Corporation
1767-450: Is a crucial aspect of determining whether or not a geotechnical engineering design for open-pit slopes is attainable. Groundwater control systems, which include dewatering and depressurization wells, may also have a large impact on local groundwater. Because of this, an optimization-based version of the control system is required to ensure that local and regional hydro-geological impacts are within acceptable ranges. Open Pit depressurization
1860-485: Is owned by Rio Tinto Group , a British-Australian multinational corporation. The copper operations at Bingham Canyon Mine are managed through Kennecott Utah Copper Corporation which operates the mine, a concentrator plant, a smelter , and a refinery . The mine has been in production since 1906, and has resulted in the creation of a pit over 0.75 miles (1,210 m) deep, 2.5 miles (4 km) wide, and covering 1,900 acres (3.0 sq mi; 770 ha; 7.7 km). It
1953-401: Is the largest artificially made excavation in the world, and is visible to the naked eye from an orbiting space shuttle . Employing some 2,000 workers, 450,000 short tons (400,000 long tons; 410,000 t) of material are removed from the mine daily. Electric shovels can carry up to 56 cubic yards (43 m) or 98 short tons (88 long tons; 89 t) of ore in a single scoop. Ore is loaded into
SECTION 20
#17327729768972046-401: Is the process of removing tensions or pressure from different areas of a mine. Depressurization helps to make open-pit mines more stable and secure. By using an integrated mine slope depressurization program the likelihood that mine plans can be achieved, and at an acceptable level of risk increase drastically. Depressurization allows considerable expansions of a mine, and can extend the life of
2139-559: Is then generally covered with soil , and vegetation is planted to help consolidate the material. Eventually this layer will erode, but it is generally hoped that the rate of leaching or acid will be slowed by the cover such that the environment can handle the load of acid and associated heavy metals. There are no long term studies on the success of these covers due to the relatively short time in which large-scale open-pit mining has existed. It may take hundreds to thousands of years for some waste dumps to become "acid neutral" and stop leaching to
2232-401: Is water-quenched to form a sand-like solid, then injected, with oxygen , into a flash-converting furnace that produces molten, 98.6-percent-pure copper. This copper is then cast into 700-pound (320 kg) anode plates and shipped by rail to the refinery. At the refinery, the anode plates are pressed flat and interleaved with stainless steel cathode blanks. Automated robotic vehicles place
2325-503: The Abercrombie landing by Miles Glacier . Initial ore shipments contained "72 percent copper and 18 oz. of silver per ton." In 1916, the peak year for production, the mines produced copper ore valued at $ 32.4 million. In 1925 a Kennecott geologist predicted that the end of the high-grade ore bodies was in sight. The highest grades of ore were largely depleted by the early 1930s. The Glacier Mine closed in 1929. The Mother Lode
2418-658: The Cretaceous Sevier orogeny . These rocks were later intruded and altered in the Tertiary by granitoid rocks. This igneous event was the source of deposition of gold, silver and other base metals . Copper and molybdenum sulfide minerals are dispersed in the intruded stock and in the adjoining carbonate sedimentary skarns . The main stratigraphic rocks in Bingham Canyon are Upper Pennsylvanian sandstones , quartzites , and limestones known as
2511-569: The Great Salt Lake . The company has come under scrutiny for the instability of the structure. The Salt Lake Tribune published a report in 2007 revealing that the company failed to disclose information on possible damages that could occur if the tailings pond collapsed in the event of a major earthquake . From 2001 through 2009 there have been six earthquakes ranging from 2.3 to 3.4 in magnitude with an average epicenter only three miles (4.8 km) away from Magna . Bingham Canyon Mine
2604-668: The Lusatian Lake District , the Central German Lake District or the Upper Palatinate Lake District. A particular concern in the formation of these lakes is acid mine drainage . Open-pit mines create a significant amount of waste. Almost one million tons of ore and waste rock can move from the largest mines per day, and a couple thousand tons moved from small mines per day. There are generally four main operations in
2697-594: The Philippines and Indonesia . In 2024, nickel mining and processing was one of the main causes of deforestation in Indonesia . Open-pit cobalt mining has led to deforestation and habitat destruction in the Democratic Republic of Congo . Open-pit mines operating in an area with heavy groundwater features may eventually face hydrology-related problems. This includes heaving and bursting of
2790-418: The mineral resource is exhausted, or an increasing ratio of overburden to ore makes further mining uneconomic. After open-pit mines are closed, they are sometimes converted to landfills for disposal of solid waste. Some form of water control is usually required to keep the mine pit from becoming a lake. Several former open-pit mines have been deliberately converted into artificial lakes, forming areas such as
2883-610: The Bingham Mine Formation in the Oquirrh Group. The central porphyry ores formed from mantle hydrothermal circulation while the outer vein and deposits in the sedimentary rocks formed at lower temperature when magmatic and meteoric waters mixed. The extracted ore is treated at the Kennecott smelter at nearby Magna, Utah . The ore is run through a concentrator, where grinding mills reduce it to
Bingham Canyon Mine - Misplaced Pages Continue
2976-826: The Dan Creek was staked by C.L. Warner and "Dan" L. Kain. Gold was found on Chititu Creek in April 1902 by Frank Kernan and Charles Koppus. Besides placer deposits, copper is found as polymetallic replacement deposits in the fault planes , fractures and joints of the Triassic Nikolai greenstone, which consists of basaltic lava flows, and in the base of the Upper Triassic Chitistone limestone . Minerals include chalcocite , bornite and chalcopyrite , with associated malachite , azurite and cuprite . Native copper can also be found in
3069-656: The US, and provided about 13-18% percent of the U.S.'s copper needs. It is one of the top producing copper mines in the world, with production at more than 18.7 million short tons (16.7 million long tons; 17.0 Mt). Every year, Kennecott produces approximately 300 thousand short tons (272 kt or 268 thousand long tons) of copper, along with 400 thousand troy ounces (13.7 short tons 12.4 tonnes, or 12.2 long tons) of gold, 4 million troy ounces (124 tonnes, 137 short tons or 122 long tons) of silver, about 10 thousand short tons (9,100 tonnes or 8,900 long tons) of molybdenum, and about
3162-487: The West Jordan claim in 1870. At first, mining was confined to placer gold, lead-silver, and copper-gold. Porphyry copper required processing and a railroad, which reached the canyon in 1873. Enos Andrew Wall started working claims in 1887. His extensive tunnels and test pits, on his 200-acre (81 ha), indicated ore containing 2% copper. The canyon's 19th Century mines were relatively small, and it wasn't until
3255-632: The affected areas to avoid regulatory laws that would have placed them on the Superfund National Priorities List (NPL). The figure above shows a comparison of two satellite images used to identify the changes in the Bingham Canyon Mine between 1985 and 2016 JuxtaposeJS Embed The Bingham Canyon ore deposits occur in the Bingham nappe . They are a porphyry copper deposit , formed by a quartz monzonite porphyry intruded into sedimentary rocks. They exhibit
3348-402: The areas surrounding open-pit mines. Open-pit gold mining is one of the highest potential mining threats on the environment as it affects the air and water chemistry. The exposed dust may be toxic or radioactive, making it a health concern for the workers and the surrounding communities. Open-pit nickel mining has led to environmental degradation and pollution in developing countries such as
3441-407: The billion-ton tailings pond would bury the homes nearby if the tailing pond's embankment failed. The mine responded by proposing various potential strategies including buying up entire subdivisions near the tailings pond , calculating the company's liability if the embankment failed, investing $ 500 million (or $ 1.3 billion today) to reinforce the embankment, and colluding with state regulators to keep
3534-530: The coarse material, or via froth flotation for the fine material. The ammonia leaching plant was built in 1915, where ammonia liquefied the copper but kept the limestone in solid form. The ammonia-copper solution was heated to drive off the ammonia, which left behind a copper oxide containing 75% copper. This was then sacked for shipment. The flotation plant was built in 1923 to process the "fines", which were less than 0.3 cm in size. These fines were mixed with water, oil, and buffering chemicals , before air
3627-431: The consistency of face powder. Flotation then separates the gangue from the metalliferous particles, which float off as a 28-percent concentrate of copper along with lesser amounts of silver , gold , lead , molybdenum , platinum and palladium . A selective flotation step separates the molybdenite ( molybdenum disulfide ) from the chalcopyrite . The filtered concentrate slurry is piped 17 miles (27 km) to
3720-583: The copper. The value of metals produced in 2006 at Bingham Canyon was US $ 1.8 billion. As of 2023, this location produced approximately 150,000 short tons (140,000 t) of copper ore per year. In 1990, homes that had been built on former flood plains were discovered to be contaminated with high levels of lead and arsenic. Activities to clean up 100 years of accumulated impacts began in the 1990s, under state Utah Department of Environmental Quality and federal oversight and are ongoing. The EPA lists "Kennecott South Zone/Bingham" on its superfund webpage, after it
3813-409: The deposit being mined, the mineral being mined, and the size of the machinery that is being used. Generally, large mine benches are 12 to 15 metres thick. In contrast, many quarries do not use benches, as they are usually shallow. Mining can be conducted on more than one bench at a time, and access to different benches is done with a system of ramps. The width of each bench is determined by the size of
Bingham Canyon Mine - Misplaced Pages Continue
3906-556: The development of low-grade copper ore adjacent to the Utah Copper Company site. Another significant development took place in 1903, when Daniel C. Jackling and Enos A. Wall organized the Utah Copper Company . Utah Copper immediately began construction of a pilot mill at Copperton , just beyond the mouth of the canyon, and the company actually started mining in 1906. The success of Utah Copper in mining
3999-424: The ecological land and water. Open-pit mining causes changes to vegetation, soil, and bedrock, which ultimately contributes to changes in surface hydrology, groundwater levels, and flow paths. Additionally, open-pit produces harmful pollutants depending on the type of mineral being mined, and the type of mining process being used. Miners typically drill a series of test holes to locate an underground ore body. From
4092-628: The end of the century that very large-scale exploitation of the canyon's ore bodies began to develop with open-pit mining . In 1896, Samuel Newhouse and Thomas Weir acquired the Highland Boy Mine, which was rich in copper, silver, and gold. Together they formed the Utah Consolidated Gold Mines, Ltd. with English investors. They then formed the Boston Consolidated Gold and Copper Co., Ltd., for
4185-497: The engineering report out of the public eye. Starting in the beginning of 1990s, dust emissions from mining began polluting surrounding areas, caused by an area near the mine where PM10 levels (particulate matter 10 μm or smaller) began to rise from 28μg/ m³ to 50 μg/m³, posing severe health concerns for residents. The first report of PM10 rising was proposed by Schwartz and Dockery in 1992. Then, in 1997, Carter (a professor at Brigham Young University ) put forward that
4278-472: The environment. The dumps are usually fenced off to prevent livestock denuding them of vegetation. The open pit is then surrounded with a fence , to prevent access, and it generally eventually fills up with ground water . In arid areas it may not fill due to deep groundwater levels. In Germany, the world's largest producer of lignite (virtually all of which these days is mined open-pit), the former mines are usually converted to artificial lakes . To mitigate
4371-480: The equipment being used, generally 20–40 metres wide. Downward ramps are created to allow mining on a new level to begin. This new level will become progressively wider to form the new pit bottom. Most walls of the pit are generally mined on an angle less than vertical. Waste rock is stripped when the pit becomes deeper, therefore this angle is a safety precaution to prevent and minimize damage and danger from rock falls. However, this depends on how weathered and eroded
4464-402: The extracted samples, they can determine the extent of the ore. This helps them determine the likely location of the veins or benches of ore and its commercial value. Open-pit mines that produce building materials and dimension stone are commonly referred to as quarries . Open-cast mines are dug on benches , which describe vertical levels of the hole. The interval of the benches depends on
4557-462: The fish population were killed in the early 1990s. In 1995 Kennecott, EPA and the State of Utah signed an agreement saying that Kennecott will continue to clean up the discharge sewage. From 2000 through 2011 the Bingham Canyon copper mine has had numerous chemical spills . The EPA has estimated a 72-square-mile (190 km) plume of contaminated groundwater has been created over the course of
4650-483: The greenstone. Copper extraction was a many step process in an attempt to be as efficient as possible. Chalcocite and covellite were sent directly to the smelting plant in Tacoma. Malachite , azurite , and other forms of copper within the limestone needed separation in the 14-story mill building before shipment. The mill was mainly built between 1909 and 1923. Ore arrived at the mill via aerial tramways, where
4743-402: The high-grade portion (approximately 60% copper) was crushed and placed in a chute to carry it directly to the bottom to be placed in burlap sacks . Lower-grade ore was further crushed, sized and sorted. The denser ore was separated from the less dense waste via Hancock jigs and shaker tables. The tailings left over after gravity separation were further treated via ammonia leaching , for
SECTION 50
#17327729768974836-645: The huge but low-grade porphyry copper type ore body at Bingham Canyon was based on Jacklin's 1904 decision to use open-pit mining, steam shovels, and the railroad. The mine became a showplace for "railroad-pit operations," and the industrial complex defined by the mine and the ASARCO smelting operation made it the "largest industrial mining complex in the world" by 1912. Utah Copper and Boston Consolidated merged after their separate surface operations approached each other in 1906. The Kennecott Copper Corporation , established to operate mines in Kennecott, Alaska , purchased
4929-457: The job was never finished and most of the town was left standing. Visitors and nearby residents have stripped many of the small items and artifacts. Some have since been returned and are held in various archives. KCC sent a field party under the geologist Les Moon in 1955. They agreed with the 1938 conclusion, "no copper resource of a size and grade sufficient to interest KCC remained." The mill and other structures remain, however, and many are in
5022-650: The location of the Bonanza claim. A few days later, Arthur Coe Spencer, U.S. Geological Survey geologist independently found chalcocite at the same location, but was too late to stake any valuable claims. Stephen Birch , a mining engineer just out of school, was in Alaska looking for investment opportunities in minerals. He had the financial backing of the Havemeyer Family , and another investor named James Ralph, from his days in New York. Birch spent
5115-582: The migrant bird populations, as well as other fish and wildlife habitats. In the northern zone near Magna, Utah , the extensive southern tailings pond has been collecting the tailings since the mine first started mining production. Kennecott Utah Copper LLC has requested permission for a Tailings Expansion Project (TEP) to expand the tailings pond impoundment in Magna, which is already at 1.8-billion-short-ton (1.6-billion-tonne) capacity, and to expand on 721 acres (1.1 sq mi; 2.9 km) of wetlands south of
5208-454: The mine by 10 to 15 years. One technique used in depressurization is annealing. Annealing is the slow heating and cooling of a metal, alloy or glass. This slow heating and cooling relieves the internal stress of surrounding areas. Annealing will increase a material's workability and durability, which overall increases open-pit mine safety. When groundwater pressures cause problems in open-pit mines, horizontal drains are used to aid in accelerating
5301-463: The mine discharge of PM10 has caused lung damage to neighboring residents. In 1995, due to scientific research showing that mining had caused the pollution of groundwater , Utah passed laws to make Kennecott companies pay $ 37 million (or $ 74 million today) to control water pollution . As a result of mine discharge sewage containing large amounts of arsenic and selenium – selenium being particularly toxic to birds, fish and amphibians – about 30% of
5394-630: The mine due to multiple spills and runoff. Long-term effects of the underground water supply contamination may include an increased demand for surface water solutions as the population of the Salt Lake valley grows since the county will not be able to tap into the groundwater supply. In 2007, Kennecott Utah Copper LLC was considering expanding its land holdings to Rose Canyon Ranch in the southern Oquirrh mountains and Yellow Fork Canyon land in Salt Lake County . Kennecott claims rights to file
5487-450: The mine floor due to excessive uplift pressure. A groundwater control system must be installed to fix problems caused by hydrology. The formation of an appropriate open-pit slope design, changes throughout the life of a mine. It is based mainly on an ever-increasing understanding of the rock mass conditions, including groundwater and associated pressures that may be acting within the slopes. The reduction of groundwater related to pore pressures
5580-464: The mine historically had adverse environmental effects on the habitats of fish and wild animals as well as air and water pollution, creating health hazards to the surrounding public. Different federal agencies concerned with environmental conservation have used strict legal rules to pressure the subsidiary of Kennecott copper mine to comply with environmental regulations. Since the early 1990s, Kennecott has spent more than $ 400 million on clean-up efforts on
5673-424: The mine. Open-pit mining Open-pit mines are used when deposits of commercially useful ore or rocks are found near the surface where the overburden is relatively thin. In contrast, deeper mineral deposits can be reached using underground mining. Open-pit mining is considered one of the most dangerous sectors in the industrial world . It causes significant effects to miners' health, as well as damage to
SECTION 60
#17327729768975766-597: The mines. In Nov. 1906, the Alaska Syndicate bought a 40 percent interest in the Bonanza Mine from the Alaska Copper and Coal Company and a 46.2 percent interest in the railroad plans of John Rosene's Northwestern Commercial Company. Political battles over the mining and subsequent railroad were fought in the office of U.S. President Theodore Roosevelt between conservationists and those having
5859-470: The mining camps were swallowed up by the ever-expanding mine. By 1980, when Lark was dismantled, only Copperton , at the mouth of Bingham Canyon and with a population of 800, remained. The 21 separate mining operations in existence by 1911 were consolidated into two in 1970: Kennecott and The Anaconda Minerals Company. In 1985 open-pit mining operations were halted by Kennecott's Utah Copper. In 1986, Kennecott discovered gold in nearby Barney's Canyon. KCC
5952-454: The organization of mining districts in the state of Utah, that extraction of ore began, and the potential of the canyon's mineral resources began to be widely recognized. The first claim located was "Jordan S.M.Co" (Silver Mining Company) on September 17, 1863, the day the district was organized. Soon followed were other mining claims, including Galina and Independence in 1864, and Buckeye and Spanish in 1865. George B. Ogilvie and 23 others located
6045-444: The prepared anodes in cells containing an acidic electrolyte . When the cells are electrified, the anodes slowly dissolve, freeing copper ions that are deposited on the cathode as 99.99-percent-pure copper. Impurities and precious metals settle to the bottom of the electrolytic cells as anode slimes . A chlorination leaching process recovers the gold and silver, which is melted in induction furnaces. Kennecott's Bingham Canyon Mine
6138-446: The presence of unextracted sulfide minerals , some forms of toxic minerals in the gangue , and often cyanide which is used to treat gold ore via the cyanide leach process . If proper environmental protections are not in place, this toxicity can harm the surrounding environment. Open-pit mining involves the process of disrupting the ground, which leads to the creation of air pollutants. The main source of air pollutants comes from
6231-407: The problem of acid mine drainage mentioned above, flooding is often done with the water of nearby rivers instead of using groundwater alone. In some cases, calcium oxide or other basic chemicals have to be added to the water to neutralize the pH -value. Gold is generally extracted in open-pit mines at 1 to 5 ppm (parts per million) but in certain cases, 0.75 ppm gold is economical. This
6324-544: The process of being restored. Kennecott first reported on the 1920 U.S. Census as an unincorporated village. It appeared again in 1930 and 1940, and after its abandonment, it has not reported separately since. It is now within the McCarthy CDP. Copper ore was discovered in a lode on Chief Nikolai's house at the mouth of Dan Creek in July 1899. The geological formations in the area were described and identified by
6417-568: The release of hazardous materials. The State of Utah proceeded with legal action against Kennecott and filed a damage claim against the mine in October 1986, for the loss and destruction of the natural resources, specifically the groundwater. There was also a threat due to the tailings dam . An engineering report in March 1988, gave information that the tailings dam overshadowing the town of Magna had threat of collapse due to an earthquake and that
6510-582: The resources extracted from the Bingham Canyon Mine is greater than the Comstock Lode , Klondike , and California gold rush mining regions combined. Mines in Chile , Indonesia , Arizona , Peru , Democratic Republic of the Congo , and Zambia exceeded Bingham Canyon's annual production rate in 2023. High molybdenum prices in 2005 made the molybdenum produced at Bingham Canyon in that year worth more than
6603-404: The rocks are, and the type of rocks involved. It also depends on the amount of structural weaknesses occur within the rocks, such as a faults , shears , joints or foliations . The walls are stepped. The inclined section of the wall is known as the batter, and the flat part of the step is known as the bench or berm. The steps in the walls help prevent rock falls continuing down the entire face of
6696-412: The slope depressurization process. Which helps to prevent large scale slope failure in the mine. Horizontal drains are used to lower pore pressure by reducing groundwater head, which enhances slope stability. A form of open-cast quarrying may be carried out as 'untopping'. This is done where a previous underground mine is becoming uneconomic or worked-out, but still leaves valuable rock in place, often as
6789-400: The smelter, where it is dried, and then injected along with oxygen into a flash smelting furnace to oxidize the iron and sulfur. The oxidized iron is skimmed off, while the sulfur dioxide gas is captured and sent to an on-site acid plant for conversion to valuable sulfuric acid – a million tons of it each year. Left behind is a molten copper sulfide called matte. The 70-percent-copper matte
6882-496: The smelters could not smelt ores containing more than 10% sulfur, effectively closing all of the aforementioned smelters. Kennecott Copper Mines was formed in 1910 after a merger of Utah Copper and Kennecott copper mining companies. By 1912, environmental protection organizations were complaining about high levels of asbestos being used in the organization. Kennecott Corporation was using asbestos for preventing fires since copper processing requires very high temperatures. Copper has
6975-516: The surrounding area. The area was designated a National Historic Landmark in 1986 and the National Park Service acquired much of the land within the Kennecott Mill Town in 1998. Popular tourist activities while visiting Kennecott include glacier hiking, ice climbing , and touring the abandoned mill. Visitors may also hike to the abandoned Bonanza, Jumbo and Erie mines, all of which are strenuous full-day hikes, with Erie Mine being
7068-465: The survival and establishment of settlements were of paramount importance at that time. The brothers applied to that purpose as directed and did not stake a claim. In 1850, the Bingham family went to settle what is now Weber County, leaving the canyon still today known by their name. Bingham mine was part of the historical West Mountain Mining District. It was not until September 17, 1863, with
7161-416: The transportation of minerals, but there are various other factors including drilling, blasting and the loading and unloading of overburden. These type of pollutants cause significant damage to public health and safety in addition to damaging the air quality. The inhalation of these pollutants can cause issues to the lungs and ultimately increase mortality. Furthermore, the pollutants affect flora and fauna in
7254-399: The valley below. The geologist Oscar Rohn named the glacier after Robert Kennicott during the 1899 US Army Abercrombie Survey. A "clerical error" resulted in the substitution of an "e" for the "i", supposedly by Stephen Birch himself. Kennecott had five mines: Bonanza, Jumbo, Mother Lode, Erie and Glacier. Glacier, which is really an ore extension of the Bonanza, was an open-pit mine and
7347-466: The wall. In some instances additional ground support is required and rock bolts , cable bolts and shotcrete are used. De-watering bores may be used to relieve water pressure by drilling horizontally into the wall, which is often enough to cause failures in the wall by itself. A haul road is usually situated at the side of the pit, forming a ramp up which trucks can drive, carrying ore and waste rock. Open-pit mines are typically worked until either
7440-474: The winter of 1901-1902 acquiring the "McClellan group's interests" for the Alaska Copper Company of Birch, Havemeyer, Ralph and Schultz, later to become the Alaska Copper and Coal Company. In the summer of 1901, he visited the property and "spent months mapping and sampling." He confirmed the Bonanza mine and surrounding by deposits were, at the time, the richest known concentration of copper in
7533-557: The world. By 1905, Birch had successfully defended the legal challenges to his property and he began the search for capital to develop the area. On June 28, 1906, he entered into "an amalgamation" with the Daniel Guggenheim and J.P. Morgan & Co., known as the Alaska Syndicate , eventually securing over $ 30 million. The capital was to be used for constructing a railway, a steamship line, and development of
7626-549: The world. Listed are the world's ten largest open-pit mines in 2015. Kennecott, Alaska Kennecott , also known as Kennicott and Kennecott Mines , is an abandoned mining camp in the Copper River Census Area in the U.S. state of Alaska that was the center of activity for several copper mines . It is located beside the Kennicott Glacier , northeast of Valdez , inside Wrangell-St. Elias National Park and Preserve . The camp and mines are now
7719-524: Was achieved by bulk heap leaching at the Peak Hill mine in western New South Wales , near Dubbo , Australia . Nickel , generally as laterite, is extracted via open-pit down to 0.2%. Copper can be extracted at grades as low as 0.11% to 0.2%. Open-pit mining is a common method to extract minerals and samples from the Earth. Due to being cost-effective, this method is very popular and is used all over
7812-424: Was also cited as contributing to emissions of heavy metals such as arsenic and mercury . By 1940, arsenic and mercury were also some of the concerns that were raised by environmental protection agencies against Kennecott Corporation . Both mercury and arsenic are dangerous to health in even small quantities. Investigations in the 1980s revealed contamination in the groundwater caused by mining operations
7905-410: Was bubbled through the solution. Copper ore attached to the air bubbles, and floated to the top, where it was skimmed off, dried and sacked. In the 1980s, Kennecott became a popular tourist destination, as people came to see the old mines and buildings. However, the town of Kennecott was never repopulated. Residents involved in the tourism industry often lived in nearby McCarthy or on private land in
7998-415: Was deserted except for a family of three who served as the watchmen until about 1952. In the late 1960s, an attempt was made to reprocess the tailings and to transport the ore in aircraft. The cost of doing so made the idea unprofitable. Around the same time, the company with land rights ordered the destruction of the town to rid them of liability for potential accidents. A few structures were destroyed, but
8091-607: Was designated a National Historic Landmark in 1966 under the name Bingham Canyon Open Pit Copper Mine . The mine experienced a massive landslide in April 2013 and a smaller slide in September 2013. Minerals, in the form of copper ore, were first discovered in Bingham Canyon in 1848 by two brothers, Sanford and Thomas Bingham, sons of Erastus Bingham, Latter-Day Saint pioneers of September 1847, who grazed their cattle there. They reported their find to their leader, Brigham Young , who advised against pursuing mining operations because
8184-589: Was featured in the 1973 made-for-TV movie Birds of Prey , with protagonist helicopter pilot Harry Walker (played by David Janssen ) piloting his Hughes 500 into the crater to track down three bank robbers and their female hostage in an Aérospatiale SA 315B Lama , which was hiding behind heavy mining machinery. It was also featured prominently in The Fundamentals of Caring . In the PC video game American Truck Simulator , players can simulate hauling cargo at
8277-495: Was next, closing at the end of July 1938. The final three, Erie, Jumbo and Bonanza, closed that September. The last train left Kennecott on November 10, 1938, leaving it a ghost town. From 1909 until 1938, except when it closed temporarily in 1932, Kennecott mines "produced over 4.6 million tons of ore that contained 1.183 billion pounds of copper mainly from three ore bodies: Bonanza, Jumbo and Mother Lode." The Kennecott operations reported gross revenues above $ 200 million and
8370-402: Was only mined during the summer. Bonanza and Jumbo were on Bonanza Ridge about 3 mi (4.8 km) from Kennecott. The Mother Lode mine was located on the east side of the ridge from Kennecott. The Bonanza, Jumbo, Mother Lode and Erie mines were connected by tunnels. The Erie mine was perched on the northwest end of Bonanza Ridge overlooking Root Glacier about 3.7 mi (6.0 km) up
8463-642: Was proposed to be listed as a superfund site in 1994. The South Zone includes the Bingham Mining District in the Oquirrh Mountains , about 25 mi (40 km) southwest of Salt Lake City, the open pit, waste rock dumps, Copperton Mill and other historic sites. The company avoided regulatory issues of being on the NPL by voluntarily cleaning up the contaminated lands, the Superfund Alternative Approach. The listing proposal
8556-516: Was purchased by Sohio in 1981, and the mine reopened in 1987 after BP Minerals purchased the assets. In 1989 the Rio Tinto Group acquired the asset, which modernized the mine, mill, and smelter. The open-pit owners replaced an antiquated 1000-car railroad with conveyor belts and pipelines for transporting the ore and waste, which reduced costs by nearly 30% and returned the operation to profitability. At 9:30 pm on April 10, 2013,
8649-570: Was withdrawn in 2008. By 1904, there were three large copper smelters and one lead smelter in the Salt Lake valley. The sulfur dioxide gas emissions from the smokestacks caused significant crop damage to neighboring crops. During the 1904–1905 winter, the farmers gathered together and decided to file suit against the smelters in the United States District Court of Utah. In 1906, Federal Court Judge Marshall ruled that
#896103